Sugar taniltsuulga eng_2
Transcript of Sugar taniltsuulga eng_2
ХОВД АГРО АЛЬФА ХХК
ХӨДӨӨ АЖ АХУЙН ИХ СУРГУУЛЬ
УРГАМАЛ ГАЗАР ТАРИАЛАНГИЙН ЭРДЭМ ШИНЖИЛГЭЭНИЙ ХҮРЭЭЛЭН
УРГАМАЛ ХАМГААЛЛЫН ХҮРЭЭЛЭН
БИОЛОГИЙН ХҮРЭЭЛЭН
ЧИХРИЙН МАНЖИН
ТАРИАЛЖ ЭЛСЭН ЧИХЭР
ҮЙЛДВЭРЛЭХ ТӨСЛИЙН
ТАНИЛЦУУЛГА
УЛААНБААТАР ХОТ 2018 ОН
2
Organizations involved in the growing sugar beet and produce sugar in Mongolia:
AGRO ALPHA Co., Ltd
MONGOLIAN UNIVERSITY OF LIFE SCIENCES INNOVATION AND BUSINESS DEVELOPMENT CENTER
INSTITUTE OF PLANT AND AGRICULTURAL SCEINCES
INSTITUTE OF PLANT PROTECTION RESEARCH
INSTITUTE OF GENERAL AND EXPERIMENT BIOLOGY, MONGOLIAN ACADEMY OF SCIENCES
THE INSTITUTE OF GEOGRAPHY AND GEOECOLOGY, MONGOLIAN ACADEMY OF SCIENCES
3
I. Features of Mongolian nature and climates
Atmosphere of Mongolia
Mongolian territory is very far from the oceans, in the center of Eurasia, surrounded by high mountains,
average elevation of 1500 meters above sea level, and thereupon has an extreme continental climate.
The main feature of the climate in Mongolia is the four-seasons difference and in this way, air temperature
fluctuations is high, low precipitation and difference between latitude and elevation range, it is evident in
the climate. In Mongolia, has short and dry summer (from June to mid-August), very cold, long winter
(from November to April) and duration of spring and autumn fluctuates varies widely from year to year.
Air heat and cold
In Mongolia, average annual temperature is 0.2°С (32°F), average temperature in winter -10°…-30°С
(14°…22°F), in summer season 10°…27°С (50°…80°F). Average annual temperature is colder than–4°С
(24.8°F), within cold from –6°C to –7.40С (21.2…18.7°F) in mountain ranges and large river valleys, warmer
than 2 ° C (35.6 ° F) in the desert steppe zone and warmer than 6 ° C (42.8 ° F) in the southern Gobi. The
0 ° C line for the average annual air temperature is located desert steppe and north of the Gobi region in
Mongolia, it is 46 degrees of north latitude. Permafrost soils are distributed in the territory as annual
average temperature of the air is below -2 ° C (28.4 ° F). During winter the absolute low temperature
reaches -28 ° C to -54 ° C (-18.4 ° ...- 65.2 ° F) and In summer, absolute temperature reaches 30 ° C to 45 °
C (86 ° ... 113 ° F).
Picture.1. Annual average air temperature
4
Precipitation
The total amount of precipitation is low in Mongolia, but amount of precipitation per year varies across
regions to cohere location of the mountains and their elevation. Particularly, Khangai, Khuvsgul, Khentii
mountain ranges, and large river valleys annual precipitation is 250-390 mm, Altain mountain range is 90-
130 mm, in steppe areas precipitation range is 180-280 mm per year. Like this, the amount of precipitation
decreases from north to south, lowest in the Gobi, it is 70-150 mm per year. In the Altai Govi Desert and
the southern boundary, there are 40-60 mm or less precipitation occurs.
Picture.2. Annual sums of precipitations
Sun consonant
Cloudiness is low in Mongolia and had many clear days. The sun to enlighten 230-260 days or 2600-3300
hours per year.
Picture.3. Sun consonant
3400-3600
hours
5
General assessment of the soil and weather conditions
Mongolia's soil and light reserves are perfect for growing sugar beet. The maturation time of
sugar beet can be shortened to our country, but it is possible to solve the problem by using seeds
of early and middle-aged. The territory of Mongolia is located at forward of 520 and after 410
north of the globe, that’s strip of same latitude with sugar beet regions of Russia and Ukraine.
Thus, sugar beets planted in our country, it is clear that the harvest can be obtained.
Therefore, the sugar beet area may be placed in the main crop region of Mongolia as follows.
These include:
In main crop region, it is recommended to planting in springs or river valleys near streams
and streams that can be used for irrigating sugar beets. For that purpose, use of the
Orkhon, Selenge and Kharaa valleys is important for sugar beet planting by heat,
moisture, and soil.
In the Eastern region, to be possible farness area have good soil with humus, climate
relatively mild and humid. In this region, the maturation of sugar beet is longer and sum
of the temperature above 50C is 25000C.
In the western region of agriculture, the Great Lakes Depression and the Mongol Altai
Mountains, such as it is possible to planting sugar beet in Khovd aimag with irrigations.
Used on the oases of the Gobi region, there is a great chance to planting sugar beets with
irrigation, but ability to planting sugar beet in large areas is limited near the springs and
oases.
To assess and evaluate opportunities for sugar beet planting under Mongolian soil and climatic
conditions, that’s different in each crop regions. For the supply of irrigation water and
infrastructure supplies for sugar production, Crop central region will be significant leading role in
the planting of sugar beets. Eastern region is in next place, but there will be a need to develop
irrigated farming and preliminary conditions for establishing sugar production plant.
6
II. Place and results of sugar beet planting research in Mongolia
Picture.4. Place of research conducted
Selenge province Mandal soum (Zuunkharaa) (1993-1996, 2014)
It is 174 km from Ulaanbaatar and 210 km from the province center. Bordered with Batsumber,
Bornuur soums of Tuv province and Yeruu and Bayangol soums of Selenge province. Total area is
484.3 thousand hectares. Connected with international railways and roads with central regions
provinces. Each year, there are cultivated grains and potatoes in 7,800 hectares.
Mandal soum has 136708 hectares of agricultural land, 309957 hectares of forest land, 2260
hectares of water reserves land, 21384 hectares of special needs land, 12826 hectares of village
land, and 1238 hectares of infrastructure land.
In geographically, is located in a forest steppe zone of 1000-2228 meters above sea level in Khan
Khentii mountain range and has Kharaa, Yaruu, Chuluut and Tunkheleg rivers.
Darkhan-Uul province Shariin gol soum (2014)
Sharyn Gol soum is located at Darkhan-Uul of the Khentii mountain range at 920 m above sea
level. It has a territory of 9553 hectares. Bordered front and west side with Bayangol and Mandal
soum of Selenge province and other side with Khongor soum of Darkhan-Uul province.
218 km from Ulaanbaatar and 70 km from Darkhan-Uul province. There is a 109.5 km long railway
connecting Darkhan and Sharyn gol, 1900 tons of diesel fuel, a 250-liter petrol storage tank.
7
Results of research planting sugar beets in Mongolia
The Government of Mongolia started in the 1990s, the program proposed, that’s planting sugar
beet and produce sugar and aimed at providing domestic production 40% of imported sugar and
sugar demand. Within the framework of this activity, the Zuunharaa city of Selenge province, to
restoration of 405 hectares of irrigation system in Shirkhentseg and in 1993-1996, it was possible
to harvest sugar beets in 200 hectares land and harvested 300 to 600 centners beets per hectare.
That was the first large-scale production and experiment of sugar beets planting by mechanized
in Mongolia's Central Crop Regions under production conditions.
Picture.5.Experiment of sugar beets plant (Zuunkharaa 1993-1996)
In addition, in 2014 the Ministry of Industry and Agriculture's decision, Scientist of Institute of
Agricultural techniques and technology, Institute of Plant and agricultural sciences, in Shariin Gol
and Zuunkharaa valley, nine types of beet varieties of Ukrainian and Polish beet (7 of which are
Ukrainian varieties) were planted in irrigation conditions in the 1.5 hectares of the area, with a
maximum yield is 25.0-35.0 tons per hectares.
Picture.6.Experiment of sugar beets. 2014-08-15. Shariin gol soum.
The results of these experiments are within the range of yield is 250-400 centner per hectares
and beet sugar content of 14 ... 23%. It shows that the sugar beet is to accept standard.
8
Sugar content of sugar beet varieties planted in Mongolia, %
№ Name of variety
Name of place
Sugar content, %
Determined date
2014.08.28 2014.09.20
А 1 2 3 4
1 Zluka Shariin gol 12,2 15,3
Zuunkharaa 13,6 18,3
2 Aleksandriya Shariin gol 12,9 19,3
Zuunkharaa 15,4 15,7
3 Yarisya Shariin gol 14,3 18,1
Zuunkharaa 12,9 15,0
4 Impact Shariin gol 12,6 21,0
Zuunkharaa 11,1 14,7
5 Goliaf Shariin gol 7,7 15,7
Zuunkharaa 10,4 16,1
6 Umansky ChS97
Shariin gol 13,6 14,3
Zuunkharaa 16,0 16,4
7 Canion Shariin gol 12,8 16,0
Zuunkharaa 10,9 14,0
8 Ramzes Shariin gol 10,0 20,7
Zuunkharaa 10,0 15,0
9 Yanka Shariin gol 12,9 19,3
Zuunkharaa 14,6 15,0
Sugar beet varieties indicators
№ Name of variety Number of plant, 𝐭𝐡𝐨𝐮𝐬.𝐩𝐜𝐬
𝐡𝐞𝐜𝐭𝐚𝐫𝐞
Yield, ton/hectare
Sugar content,%
A 1 2 3 4
1 Umansky ChS97 89,0 33,76 16,7
2 Goliaf 67,0 25,10 20,0
3 Yarisya 67,0 23,00 16,05
4 Aleksandriya 67,0 22,24 15,9
5 Canion 61,0 21,00 16,3
6 Ramzes 60,0 20,79 18,3
7 Zluka 60,0 20,74 21,7
8 Impact 57,0 19,65 20,02
9 Yanka 52,0 17,98 15,3
9
The first place was Ukrainian "Umansky ChS97", in second place is Ukrainian "Goliaf" varieties by
yield of sugar beet harvested from 1 hectare area. However, there is a lot of wild plants during
germination, so it is thought that the sugar beet harvest is reduced by 40%. The sugar content of
beet varieties varies between 15% and 22%, which is higher than the standard (more than 14%).
III. Current Situation of region of project accomplish
Picture.7. Region of project accomplish
Western region
Included 91 soums of Khovd, Bayan-Ulgii, Gobi-Altai, Uvs and Zavkhan provinces. Total area is 415,300 км². Bordered with Kazakhstan and Republic China, Russian Federation.
Brief information of western regions provinces
Provinces Khovd Bayan-
Ulgii Gobi-Altai Zavkhan Uvs Total
Soums 17 13 18 24 19 91
Center of
provinces Khovd Ulgii Altai Uliastai Ulaangom
Year of
Establishment 1931 1940 1940 1923 1925
Territory 76,1 кm² 45,8 кm² 141.4 кm² 82,4 кm² 69,6 кm² 415.3 кm²
Population 83.5
thousand
93
thousand
53,6
thousand
69,7
thousand
75,7
thousand
375.5
thousand
10
The demand for sugar in the western region is around 15 thousand tons per year and this demand
will increase further. Therefore, the project is expected to meet the demand for sugar in the
western region
Khovd province
The infrastructure, power, transportation,
telecommunications is relatively well developed in the
Khovd province and connected with the main paved
road with Ulaanbaatar city and China Republic. Khovd
province has 17 soums and 91 bags. Total population is
78449. The agriculture sector, which is the main
economic sector of the provinces, accounts for 56.5%
of the Gross Domestic Product (GDP) of 64.8 billion
MNT. 7320 herder households run livestock production
and 15269 herders work in the livestock sector. A total
of 6833.7 hectares of cultivated land was planted and
27207.9 tons of harvested yields, including 398.6
thousand tons of grain, 14358.8 tons of potatoes and
1101.9 tons of vegetables and 11348.6 tons of fodder
plants.
Khovd province Erdeneburen soum
Erdeneburen soum has 277.2 hectares of land, of that 6431 hectares of crop field and 273
hectares of hayfields. For geographical location, included in the Great Lakes Depression. It has an
area of 1182-4208 m above sea level, combined with high mountains and Gobi steppe.
Erdeneburen soum bordered by north side with Tolbo, Altantsugts and Bayannuur soum of
Bayan-Ulgii province, by east side with Myangad soum Khovd province, by south side with Buyant
soum, by west side by Khovd soum. 61 km from the province center and 1486 km from the capital
city.
Picture.8. Khovd province
11
Results of soil analysis of Erdeneburen soum, Khovd province
12
13
IV. Sugar consumption and market research
As we know, white powder is called sucrose. Carbohydrates consist of glucose and fructose are
combined. Sucrose are contained in most plants, but are mostly contained in sugar beets and
sugar cane. Therefore, 75% of the world's sugar produces from sugar cane. In 1747, knowing that
the sugar beet was contain sugar, and this plant became the raw material for the remaining 25
percent.
World sugar production
2014-2016 average
2017
In world
SUGAR BEET
Production Thous ton 261.9 276.3
Field Mil hec 4.5 4.6
Yield Tons/hec 58.72 59.99
Used in biodiesel Мян.тн 13.2 11.4
SUGAR CANE
Production Thous.ton 1 844.0 1 918.8
Field M hec 27.0 27.7
Yield Tons/hec 68.39 69.34
Used in biodiesel Thous ton 343.5 362.6
SUGAR
Production Mil ton 168.6 179.2
Consumption Mil ton 168.3 174.3
Price, raw sugar (1) $/ton 361.6 403.2
Price, white sugar (2) $/ton 429.9 487.7
Price, High concentration of fructose syrup (3) $/ton 651.5 609.5
14
Mongolia imports 100% of sugar. Last year, our country imported sugar from 11 countries, with most of
it being imported from Thailand. In the first five months of this year, imports of sugar can be 46% by
Thailand, Guatemala and 21.6%, and India by 20%. In comparison with previous years, sugar imports
increased by around 20 percent and reached $ 9.8 million. In terms of size, increased by 21% and it is
reached 50.9 thousand tons.
Picture.9. Study of
Mongolian sugar
imports, 2016
Picture.10. Study of Mongolian price of sugar
As of the end of 2015, the average price of sugar was 1785 MNT, which reached MNT 2315 in
2016 and increased by 530 MNT (23.0%). This growth lasts to 2017, reaching 2625 MNT and has
increased by 47% since 2015.
In order to calculate population estimates from physiology, our country needs 130.0 thousand
tons of sugar a year. It is important to solve by domestic production not less than 50% of our
1667 1733 1667 1730 1785
23152625
2011 2012 2013 2014 2015 2016 2017
AVERAGE PRICE OF SUGAR, TUGRUG/KG
15
needs and Mongolia has enough reserves of soil and weathers to planting sugar beet and sugar
of beet is best quality.
Therefore, it is necessary to planting sugar beet in order to increase sugar production.